5.7 Pursuit Air Cleaner MISBUILD (09-007-17)

WARNING: This page is about the Charger GT, which is a different variant/trim than selected.

Publication date: 2017-12-01
Reference number: 09-007-17

5.7 PURSUIT AIR CLEANER MISBUILD

TECHNICAL SERVICE BULLETIN

Reference Number(s): 09-007-17, Date of Issue: December 01, 2017

CHRYSLER:	2018 (LD) Dodge Charger
GROUP:	09 - Engine

NOTE: THIS SERVICE BULLETIN IS ALSO BEING RELEASED AS RAPID RESPONSE TRANSMITTAL (RRT) 17-109. ALL APPLICABLE SOLD AND UNSOLD RRT VIN's HAVE BEEN LOADED. TO VERIFY THAT THIS RRT SERVICE ACTION IS APPLICABLE TO THE VEHICLE, USE VIP OR PERFORM A VIN SEARCH IN TECHCONNECT. ALL REPAIRS ARE REIMBURSABLE WITHIN THE PROVISIONS OF WARRANTY.

SUBJECT

5.7 Pursuit Air Cleaner Misbuild

OVERVIEW

This bulletin involves inspecting and if necessary, replacing the air cleaner to correct the incorrect parts installed from the factory.

MODELS

MODELS CHART

2018

(LD)

Dodge Charger

NOTE: This bulletin applies to vehicles within the following markets/countries: NAFTA.

NOTE: This bulletin applies to vehicles built on or after August 16, 2017 (MDH 0816XX) and on or before October 14, 2017 (MDH 1014XX) equipped with a 5.7L V8 Hemi MDS VVT Engine (Sales Code EZH) and Police Group (Sales Code AHB).

SYMPTOM/CONDITION

The air cleaner assembly change will improve the water fording capabilities of the pursuit vehicles.

DIAGNOSIS

If a customer's VIN is listed in VIP or your RRT VIN list, perform the repair. This RRT only applies to vehicles on the RRT VIN list.

INSPECTION

Remove the top of the air cleaner assembly as well as the air filter element to examine the lower air cleaner assembly.
Is there a hole in the side of the lower portion of the air cleaner assembly (Fig. 1) ?
- YES>>> This bulletin has been completed. Use inspection LOP (14-10-01-96) to close the active RRT
- NO>>> Continue to the Repair Procedure. Proceed to Step 1 .

PARTS REQUIRED

PARTS DESCRIPTION CHART

Qty.	Part No.	Description
1	52030462AC	Air Cleaner Assembly

REPAIR PROCEDURE

Replace the air cleaner assembly. Refer to the detailed service procedures available in DealerCONNECT> TechCONNECT under: 09 - Engine, 5.7L/Air Intake System/Air Cleaner/Removal/Installation.

POLICY

Reimbursable within the provisions of the warranty.

TIME ALLOWANCE

TIME ALLOWANCE CHART

Labor Operation No:	Description	Skill Category	Amount
14-10-01-96	Air Cleaner Assembly - Inspect (0 - Introduction)	1 - Engine Repair and Performance	0.2 Hrs.
14-10-01-97	Air Cleaner Assembly - Inspect and Replace (0 - Introduction)	1 - Engine Repair and Performance	0.2 Hrs.

FAILURE CODE

FAILURE CODE CHART

ZZ	Service Action